力士樂Rexroth流量控制閥2FRM6B36-3X/6QRV

電磁閥故障與排除

一、電磁閥通電后不工作
檢查電源接線是否不良→重新接線和接插件的連接
檢查電源電壓是否在±工作范圍-→調致正常位置范圍
線圈是否脫焊→重新焊接
線圈短路→更換線圈
工作壓差是否不合適→調整壓差→或更換相稱的電磁閥
流體溫度過高→更換相稱的電磁閥
有雜質使電磁閥的主閥芯和動鐵芯卡死→進行清洗，如有密封損壞應更換密封并安裝過濾器
液體粘度太大，頻率太高和壽命已到→更換產品
二、電磁閥不能關閉
主閥芯或鐵動芯的密封件已損壞→更換密封件
流體溫度、粘度是否過高→更換對口的電磁閥
有雜質進入電磁閥產閥芯或動鐵芯→進行清洗
彈簧壽命已到或變形→更換
節流孔平衡孔堵塞→及時清洗
工作頻率太高或壽命已到→改選產品或更新產品
三、其它情況
內泄漏→檢查密封件是否損壞，彈簧是否裝配不良
外泄漏→連接處松動或密封件已壞→緊螺絲或更換密封件
通電時有噪聲→頭子上堅固件松動，擰緊。電壓波動不在允許范圍內，調整好電壓。鐵芯吸合面雜質或不平，及時清洗或更換。
現場快速判斷電磁閥好壞方法

力士樂Rexroth流量控制閥2FRM6B36-3X/6QRV

Rexrot流量控制閥2FRM、2FRH、2FR 
rexroth訂貨號R900205507    2FRM6B36-3X/1,5QRV
rexroth訂貨號R900205508    2FRM6B36-3X/10QMV
rexroth訂貨號R900205509    2FRM6B36-3X/10QRV
rexroth訂貨號R900205510    2FRM6B36-3X/16QMV
rexroth訂貨號R900205511    2FRM6B36-3X/16QRV
rexroth訂貨號R900205512    2FRM6B36-3X/25QMV
rexroth訂貨號R900205513    2FRM6B36-3X/25QRV
rexroth訂貨號R900205514    2FRM6B36-3X/32QMV
rexroth訂貨號R900205515    2FRM6B36-3X/32QRV
rexroth訂貨號R900205517    2FRM6B36-3X/3QRV
rexroth訂貨號R900205518    2FRM6B36-3X/6QMV
rexroth訂貨號R900205519    2FRM6B36-3X/6QRV
rexroth訂貨號R900205521    2FRM6B76-3X/16QMV
rexroth訂貨號R900205523    2FRM6B76-3X/25QMV
rexroth訂貨號R900205524    2FRM6B76-3X/25QRV
rexroth訂貨號R900205527    2FRM6B76-3X/6QMV
rexroth訂貨號R900205580    2FRM6B36-3X/0,2QRV
rexroth訂貨號R900209927    2FRM6B76-3X/10QRV
rexroth訂貨號R900210900    2FRM6B76-3X/1,5QMV
rexroth訂貨號R900211134    2FRM6A36-3X/10QMV
rexroth訂貨號R900214778    2FRM6A76-3X/1,5QMV
rexroth訂貨號R900216559    2FRM6A76-3X/16QMV
rexroth訂貨號R900221158    2FRM6SB36-3X/32QRV
rexroth訂貨號R900225234    2FRM6A36-3X/0,2QRV
rexroth訂貨號R900420286    2FRM10-3X/50L
rexroth訂貨號R900420287    2FRM16-3X/100LB
rexroth訂貨號R900423251    2FRM10-3X/16L
rexroth訂貨號R900423252    2FRM10-3X/16LB
rexroth訂貨號R900423255    2FRM10-3X/25L
rexroth訂貨號R900423256    2FRM10-3X/25LB
rexroth訂貨號R900423261    2FRM10-3X/50LB
rexroth訂貨號R900424034    2FRM16-3X/160LBV
rexroth訂貨號R900424898    2FRM10-3X/50LBV
rexroth訂貨號R900424902    2FRM16-3X/160LB
rexroth訂貨號R900424905    2FRM16-3X/100L
rexroth訂貨號R900424906    2FRM16-3X/160L
rexroth訂貨號R900427776    2FRM10-3X/50LV
rexroth訂貨號R900427777    2FRM16-3X/160LV
rexroth訂貨號R900471183    2FRM16-3X/100LBV
rexroth訂貨號R900549687    Z2FRM6CB2-2X/32QRV
rexroth訂貨號R900757849    2FRM6A36-3X/0,2QMV
rexroth訂貨號R900908807    Z2FRM6TB2-2X/32QRV
rexroth訂貨號R900986124    2FRM6A36-3X/32QMV
rexroth訂貨號0811403119    2FREX6B-1X/35L1G24-25N9Z4MM-254
2FRM型調速閥是兩通的流量控制閥，上海韋米機電銷售此閥是由減壓閥和節流閥串聯構成的。油流進入調速閥后，先經閥減壓，再由節流閥節流。由于減壓閥對節流閥進行了壓力補償，所以調速閥的流量不受負載變化的影響。同時節流窗口設計成薄刃狀，流量受溫度變化很小。調速閥與單向閥并聯時，油流能反向回流。Z4S型整在調速閥下，可以穩定通過調速閥兩個方向的流量